MATHESON TRI-GAS, INC. -- ETHYLENE GLYCOL DIMETHYL ETHER -- - 
=====================  Product Identification  =====================

Product ID:ETHYLENE GLYCOL DIMETHYL ETHER
MSDS Date:Jan 24 1989
Kit Part:=== Responsible Party ===
Company Name:MATHESON TRI-GAS, INC.
Address:959 ROUTE 46 EAST
City:PARSIPPANY
State:NJ
ZIP:07054-0624
Country:US
Info Phone Num:(USA) 973-257-1100, (WHITBY) 905-668-3570, (EDMONTON)
    780-471-4036
Chemtrec Ind/Phone:18004249300
=== Contractor Identification ===
Company Name:MATHESON TRI-GAS, INC.
Address:959 ROUTE 46 EAST
Box:City:PARSIPPANY
State:NJ
ZIP:07054-0624
Country:US
Phone:(USA) 973-257-1100, (WHITBY) 905-668-3570, (EDMONTON)
    780-471-4036
CAGE:Company Name:MATHESON TRI-GAS, INC.
Address:530 WATSON STREET
Box:City:WHITBY
State:ZIP:L1N 5R9
Country:ONTARIO, CANADA
Phone:(USA) 973-257-1100, (WHITBY) 905-668-3570, (EDMONTON)
    780-471-4036
CAGE:


=============  Composition/Information on Ingredients  =============

Ingred Name:ETHYLENE GLYCOL DIMETHYL ETHER
CAS:110-71-4
Fraction by Wt: 100.0%

=====================  Hazards Identification  =====================

Reports of Carcinogenicity:NTP:No    IARC:No	OSHA:No
Medical Cond Aggravated by Exposure:

=======================  First Aid Measures  =======================

First Aid: INHALATION: If adverse effects occur, remove to
    uncontaminated area. Give artificial respiration if not breathing.
    Get immediate medical attention. SKIN CONTACT: Wash skin with soap
    and water for at least 15 minutes while removing contaminated
    clothing and shoes. Get medical attention, if needed. Thoroughly
    clean and dry contaminated clothing and shoes before reuse. EYE
    CONTACT: Flush eyes with plenty of water for at least 15 minutes.
    Then get immediate medical attention. INGESTION: If vomiting
    occurs, keep head lower than hips to help prevent aspiration. If
    person is unconscious, turn head to side. Get medical attention
    immediately. NOTE TO PHYSICIAN: For ingestion, consider gastric
    lavage. Consider oxygen.

=====================  Fire Fighting Measures  =====================

Flash Point:21 F (-6 C) (CC)
Autoignition Temp:396 F (202 C)
Lower Limits:1.6%
Upper Limits:10.4%
Extinguishing Media:alcohol resistant foam, carbon dioxide, regular dry
    chemical, water Large fires: Use alcohol-resistant foam or flood
    with fine water spray.
Fire Fighting Procedures:Move container from fire area if it can be
    done without risk. Cool containers with water spray until well
    after the fire is out. Stay away from the ends of tanks. For fires
    in cargo or storage area: Cool containers with water from unmanned
    hose holder or monitor nozzles until well after fire is out. If
    this is impossible then take the following precautions: Keep
    unnecessary people away, isolate hazard area and deny entry. Let
    the fire burn. Withdraw immediately in case of rising sound from
    venting safety device or any discoloration of tanks due to fire.
    For tank, rail car or tank truck: Evacuation radius: 800 meters
    (1/2 mile). Do not attempt to extinguish fire unless flow of
    material can be stopped first. Flood with fine water spray. Do not
    scatter spilled material with high-pressure water streams. Cool
    containers with water spray until well after the fire is out. Apply
    water from a protected location or from a safe distance. Avoid
    inhalation of material ocombustion by-products. Stay upwind and
    keep out of low areas.
Unusual Fire/Explosion Hazard:Severe fire hazard. The vapor is heavier
    than air. Vapors or gases may ignite at distant ignition sources
    and flash back. Vapor/air mixtures are explosive. May form
    explosive peroxides.

==================  Accidental Release Measures  ==================

Spill Release Procedures:Avoid heat, flames, sparks and other sources
    of ignition. Stop leak if possible without personal risk. Reduce
    vapors with water spray. Small spills: Absorb with sand or other
    non-combustible material. Collect spilled material in appropriate
    container for disposal. Large spills: Dike for later disposal.
    Remove sources of ignition. Keep unnecessary people away, isolate
    hazard area and deny entry.
Neutralizing Agent:

======================	Handling and Storage  ======================

Handling and Storage Precautions:Store and handle in accordance with
    all current regulations and standards. Subject to storage
    regulations: U.S. OSHA 29 CFR 1910.106. Grounding and bonding
    required. Keep separated from incompatible substances. Avoid
    contact with air or light. May form explosive peroxides. Store in a
    cool, dry place. Store under an inert atmosphere.
Other Precautions:

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection: ETHYLENE GLYCOL DIMETHYL ETHER: 5 ppm
    recommended TWA (FERRO CORPORATION)
Ventilation:Ventilation equipment should be explosion-resistant if
    explosive concentrations of material are present. Provide local
    exhaust ventilation system. Ensure compliance with applicable
    exposure limits.
Protective Gloves:Wear appropriate chemical resistant gloves.
Eye Protection:Wear splash resistant safety goggles. Provide an
    emergency eye wash fountain and quick drench shower in the
    immediate work area.
Other Protective Equipment:Wear appropriate chemical resistant
    clothing.
Supplemental Safety and Health
 ETHYLENE GLYCOL DIMETHYL ETHER: 5 ppm recommended TWA (FERRO
    CORPORATION)

==================  Physical/Chemical Properties  ==================

Boiling Pt:181-185 F (83-85 C) @ 760 mmHg
Melt/Freeze Pt:-92 to -72 F (-69 to -58 C)
Vapor Pres:61.2 mmHg @ 20 C
Vapor Density:3.1
Spec Gravity:0.8683
pH:8.2
Evaporation Rate & Reference:4.99 (butyl acetate=1)
Solubility in Water:soluble
Appearance and Odor:PHYSICAL STATE:liquid APPEARANCE:clear
    COLOR:colorless ODOR:sweet odor
Corrosion Rate:

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:May form explosive peroxides.
    Avoid prolonged storage or contact with air, light or storage and
    use above room temperature.
Stability Condition to Avoid:Avoid heat, flames, sparks and other
    sources of ignition. Containers may rupture or explode if exposed
    to heat. Keep out of water supplies and sewers.
Hazardous Decomposition Products:Thermal decomposition products or
    combustion: oxides of carbon Thermal decomposition products or
    combustion: oxides of carbon
Conditions to Avoid Polymerization:Will not polymerize.

===================  Toxicological Information	===================

Toxicological Information:ETHYLENE GLYCOL DIMETHYL ETHER: TOXICITY
    DATA: 3200 mg/kg oral-mouse LD50 LOCAL EFFECTS: Irritant:
    inhalation, skin, eye ACUTE TOXICITY LEVEL: Moderately Toxic:
    ingestion MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: skin disorders
    REPRODUCTIVE EFFECTS DATA: Available.

=====================  Ecological Information  =====================

Ecological:Not available

====================  Disposal Considerations  ====================

Waste Disposal Methods:Subject to disposal regulations: U.S. EPA 40 CFR
    262. Hazardous Waste Number(s): D001. Dispose in accordance with
    all applicable regulations.

===================  MSDS Transport Information  ===================

Transport Information:U.S. DOT 49 CFR 172.101: PROPER SHIPPING NAME:
    1,2-Dimethoxyethane ID NUMBER: UN2252 HAZARD CLASS OR DIVISION: 3
    PACKING GROUP: II LABELING REQUIREMENTS: Flammable liquid

=====================  Regulatory Information  =====================

SARA Title III Information:  SARA TITLE III SECTION 302 EXTREMELY
    HAZARDOUS SUBSTANCES (40 CFR 355.30): Not regulated.  SARA TITLE
    III SECTION 304 EXTREMELY HAZARDOUS SUBSTANCES (40 CFR 355.40): Not
    regulated.	SARA TITLE III SARA SECTIONS 311/312 HAZARDOUS
    CATEGORIES (40 CFR 370.21):   ACUTE: Yes  CHRONIC: No  FIRE: Yes 
    REACTIVE: No  SUDDEN RELEASE: No  SARA TITLE III SECTION 313 (40
    CFR 372.65):   ETHYLENE GLYCOL DIMETHYL ETHER
Federal Regulatory Information:CERCLA SECTIONS 102a/103 HAZARDOUS
    SUBSTANCES (40 CFR 302.4): Not regulated. OSHA PROCESS SAFETY
    (29CFR1910.119): Not regulated.
State Regulatory Information: California Proposition 65: Not regulated.

=======================  Other Information  =======================

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.